Development and Application of a Portable Heavy Metal Ion Detector Based on Three Electrodes

GAO Jun-han; ZHAO Jie; DENG Yu-heng; YUAN Jian-ying; CUI Guo-feng

doi:10.19969/j.fxcsxb.23041402

您当前的位置：

首页 >

文章列表页 >

Development and Application of a Portable Heavy Metal Ion Detector Based on Three Electrodes

Scientific Papers | 更新时间：2023-09-19

- Development and Application of a Portable Heavy Metal Ion Detector Based on Three Electrodes
- Journal of Instrumental Analysis Vol. 42, Issue 9, Pages: 1096-1103(2023)
- 作者机构：
  
  1.华南理工大学机械与汽车工程学院，广东广州 510640
  2.中山大学化学学院，广东广州 510275
  3.中山大学广东省低碳化学与过程节能重点实验室，广东广州 510275
- 作者简介：
- 基金信息：
- DOI：10.19969/j.fxcsxb.23041402
  CLC：
扫描看全文
高鋆函,赵杰,邓宇珩等.基于三电极的便携式重金属离子检测仪研制与应用[J].分析测试学报,2023,42(09):1096-1103.

GAO Jun-han,ZHAO Jie,DENG Yu-heng,et al.Development and Application of a Portable Heavy Metal Ion Detector Based on Three Electrodes[J].Journal of Instrumental Analysis,2023,42(09):1096-1103.
高鋆函,赵杰,邓宇珩等.基于三电极的便携式重金属离子检测仪研制与应用[J].分析测试学报,2023,42(09):1096-1103. DOI： 10.19969/j.fxcsxb.23041402.

GAO Jun-han,ZHAO Jie,DENG Yu-heng,et al.Development and Application of a Portable Heavy Metal Ion Detector Based on Three Electrodes[J].Journal of Instrumental Analysis,2023,42(09):1096-1103. DOI： 10.19969/j.fxcsxb.23041402.

摘要

该文研制了一种小型化重金属离子检测仪。该仪器具有高精度、稳定、便携等优点，能够精准输出-2.5 ~ +2.5 V范围内的激励信号，通过调节8种不同的增益，可检测pA ~ mA范围内的电流，满足痕量重金属离子的检测需求。验证了检测仪的4项硬件参数性能，包括：激励信号输出精度、恒电位电路的稳定性、微小电流检测的准确性以及整体伏安性能测试。电化学性能通过在铁氰化钾溶液中以不同扫描速率的循环伏安实验进行验证，得出峰值电流高度与扫描速率的平方根呈线性关系，相关系数（,r,2,）均大于0.99。以未经修饰的丝网印刷金电极作为传感器，采用方波阳极溶出伏安法（SWASV）检测Pb,2+,，得到10 ~ 100 μg/L质量浓度范围内的校准曲线，检出限达0.295 μg/L，且重复性良好。通过与台式电化学分析设备Gamry Reference 600+进行比较，得到近乎一致的校准曲线，,r,2,分别为0.998 9和0.999 1，体现了所研制仪器的可靠性。该仪器在提供强大的检测性能和可靠性的同时，实现了低成本和便携性，可用于环境水体中重金属离子的现场检测。

Abstract

Heavy metal ions in environmental water are extremely harmful to human health and the ecological environment. This paper proposes a miniaturized heavy metal ion detector，which has the advantages of high precision，stability，and portability. The device can accurately output excitation signals in the -2.5-+2.5 V range，and by adjusting 8 different gains，it can detect the current in range of pA-mA to meet the detection requirements of trace heavy metal ions. Four tests are carried out to verify the hardware parameter performance of the heavy metal detector，including：the accuracy of the stimulus signal，the stability of the potentiostatic circuit，the accuracy of microcurrent detection and the overall volt-ampere performance test. The electrochemical performance was verified by cyclic voltammetry experiments at different scanning speeds in potassium ferricyanide solution，and the linear relationship between the peak current height and the square root of scanning speed was obtained，and the linear correlation coefficients（,r,2,） were all greater than 0.99. Square wave anodic stripping voltammetry（SWASV） was used to detect Pb,2+, with unmodified screen printed gold electrode as the sensor. The calibration curve in the concentration range of 10-100 μg/L was obtained，and the detection limit was 0.295 μg/L with good repeatability. By comparing with the bench-top electrochemical analytical equipment Gamry Reference 600+，nearly consistent calibration curves were obtained，with ,r,2, being 0.998 9 and 0.999 1，respectively，indicating the reliability of the developed equipment. The proposed heavy metal detector not only provides strong detection performance and reliability，but also achieves low cost and portability，and can be used for on-site detection of heavy metal ions in environmental water.

关键词

恒电位仪电化学重金属离子检测铅方波阳极溶出伏安法微电流检测

Keywords

potentiostatelectrochemistryheavy metal ion detectionleadsquare wave anodic stripping voltammetrymicrocurrent sensing

references

Yin K，Wang Q N，Lv M，Chen L X. Chem. Eng. J.，2019，360：1553-1563.

Bolisetty S，Peydayesh M，Mezzenga R. Chem. Soc. Rev.，2019，48（2）：463-487.

Kim K，Kwon H，Hong Y. Neurotoxicology，2016，53：193-200.

Bellinger D C. Curr. Opin. Pediatr.，2008，20（2）：172-177.

Sobin C，Flores-Montoya M G，Gutierrez M，Parisi N，Schaub T. Neurotoxicol. Teratol.，2015，47：137-145.

Kasten-Jolly J，Lawrence D A. Toxicol. Appl. Pharmacol.，2017，334：142-157.

Mohammadyan M，Moosazadeh M，Borji A，Khanjani N，Rahimi M S. Environ. Monit. Assess.，2019，191（3）：184-189.

Zhang Z Q，Wang J J，Ali A，Delaune R D. Environ. Monit. Assess.，2016，188（11）：628.

GB3838-2002. Environmental Quality Standards for Surface Water. National Standards of the People's Republic of China（地表水环境质量标准. 中华人民共和国国家标准）.

Ferreira S L C，Bezerra M A，Santos A S，Dos Santos W N L，Novaes C G，de Oliveira O M C，Oliveira M L，Garcia R L. TrAC，Trends Anal. Chem.，2018，100：1-6.

Luo S Y，Liang Q X，Xing W L，Liang Y Q，Deng Z Y，Liu X L. J. Instrum. Anal.（罗松英，梁绮霞，邢雯淋，梁艺琼，邓子艺，刘显兰. 分析测试学报），2020，39（3）：308-314.

Nyaba L，Nomngongo P N. Food Chem.，2020，322：126749.

Pearson D，Chakraborty S，Duda B，Li B，Weindorf D C，Deb S，Brevik E，Ray D P. J. Hydrol.，2017，（544）：172-179.

Lei Z R，Chen L，Hu K，Yang S，Wen X. Spectrochim. Acta A，2018，203：522-527.

Lu Y Y，Liang X Q，Niyungeko C，Zhou J J，Xu J M，Tian G M. Talanta，2018，178：324-338.

Bansod B，Kumar T，Thakur R，Rana S，Singh I. Biosens. Bioelectron.，2017，94：443-455.

Rowe A A，Bonham A J，White R J，Zimmer M P，Yadgar R J，Hobza T M，Honea J W，Ben-Yaacov I，Plaxco K W，Wanunu M. Plos One，2011，6（9）：e23783.

Lopin P，Lopin K V，Rolandi M. Plos One，2018，13（7）：e201353.

Adams S D，Doeven E H，Quayle K，Kouzani A Z. IEEE Access，2019，7：31903-31912.

Umar S N H，Akhtar M N，Bakar E A，Kamaruddin N M，Othman A R. Appl. Sci.，2020，10（21）：7804.

Dryden M D，Wheeler A R. Plos One，2015，10（10）：e140349.

Analog Devices. LTC3260，Low Noise Dual Supply Inverting Charge Pump. ［2023-04-13］. https：//www.analog.com/media/en/technical-documentation/data-sheets/ltc3260.pdfhttps://www.analog.com/media/en/technical-documentation/data-sheets/ltc3260.pdf.

Texas Instruments. OPA392，Single，Low-offset（0.01 mV），Low-noise（6 nV/rtHz），Femtoampere Bias Current，RRIO，e-trim™ op amp. ［2023-04-13］. https：//www.ti.com/lit/ds/symlink/opa392.pdf？https://www.ti.com/lit/ds/symlink/opa392.pdf?

Texas Instruments. LMP7721，3 Femtoampere Input Bias Current Precision Amplifier. ［2023-04-13］. https：//www.ti.com/lit/ds/symlink/lmp7721.pdf？https://www.ti.com/lit/ds/symlink/lmp7721.pdf?

Huang H K，Duan N X，Zou Y T，Gu F Y，Liu G L，Zhao X J. J. Instrum. Anal.（黄泓凯，段宁馨，邹玉婷，古飞燕，刘功良，赵晓娟. 分析测试学报），2022，41（11）：1707-1712.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Investigation on a Pb2+ Sensor Based on Polytyrosine/Bi/GC Electrode

Preparation of a Perovskite Nanocrystal Core-Shell Structure and Application in Heavy Metal Ion Detection

Application of Smartphone based Detection in Food Safety

Related Author

No data

Related Institution

生物基材料与能源教育部重点实验室

华南农业大学材料与能源学院

Suzhou Fengji Energy Technology Co.，Ltd.

School of Materials Science and Engineering，Changzhou University

Address：100 Xianlie Middle Road, Guangzhou Postal code：510070
Tel：020-87684776,37656606 Fax：020-87684776 Email：fxcsxb@china.com
Technical support is provided by Beijing Founder electronics co., LTD 粤ICP备12017312号-3 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰