Investigation on the Relative Sensitivity Factor Correction Method of 14 Trace Elements in Powdered Superalloy by Glow Discharge Mass Spectrometry

HAN Tao; GAO Song; ZHANG Yi-bo; TIAN Yue-ming; ZHANG Tao; ZHENG Song-bo

doi:10.12452/j.fxcsxb.240628177

您当前的位置：

首页 >

文章列表页 >

Investigation on the Relative Sensitivity Factor Correction Method of 14 Trace Elements in Powdered Superalloy by Glow Discharge Mass Spectrometry

Aerospace New Materials Testing Column | 更新时间：2024-11-04

- Investigation on the Relative Sensitivity Factor Correction Method of 14 Trace Elements in Powdered Superalloy by Glow Discharge Mass Spectrometry
- Journal of Instrumental Analysis Vol. 43, Issue 9, Pages: 1356-1361(2024)
- 作者机构：
  
  1.中国航发北京航空材料研究院，北京 100095
  2.航空材料检测与评价北京市重点实验室，北京 100095
  3.中国航空发动机集团材料检测与评价重点实验室，北京 100095
- 作者简介：
- 基金信息：
- DOI：10.12452/j.fxcsxb.240628177
  CLC： O657.6;TG132.3
- Published：15 September 2024，
  
  Received：28 June 2024，
  
  Revised：20 July 2024，
- 稿件说明：
移动端阅览
韩弢,高颂,张轶波,田悦鸣,张涛,郑松波.辉光放电质谱法对粉状高温合金中14种痕量元素的相对灵敏度因子校正方法探究[J].分析测试学报,2024,43(09):1356-1361.

HAN Tao,GAO Song,ZHANG Yi-bo,TIAN Yue-ming,ZHANG Tao,ZHENG Song-bo.Investigation on the Relative Sensitivity Factor Correction Method of 14 Trace Elements in Powdered Superalloy by Glow Discharge Mass Spectrometry[J].Journal of Instrumental Analysis,2024,43(09):1356-1361.
韩弢,高颂,张轶波,田悦鸣,张涛,郑松波.辉光放电质谱法对粉状高温合金中14种痕量元素的相对灵敏度因子校正方法探究[J].分析测试学报,2024,43(09):1356-1361. DOI： 10.12452/j.fxcsxb.240628177.

HAN Tao,GAO Song,ZHANG Yi-bo,TIAN Yue-ming,ZHANG Tao,ZHENG Song-bo.Investigation on the Relative Sensitivity Factor Correction Method of 14 Trace Elements in Powdered Superalloy by Glow Discharge Mass Spectrometry[J].Journal of Instrumental Analysis,2024,43(09):1356-1361. DOI： 10.12452/j.fxcsxb.240628177.

摘要

该文通过辉光放电质谱法（GDMS）对3种不同粒度段FGH96高温合金粉末中14种关键痕量元素的相对灵敏度因子（RSF）进行了系统分析，并首次将不对称电荷转移（ACT）理论应用于镍基高温合金中Mg元素的RSF系数校正。实验结果显示，B、P、S等13种痕量元素的RSF系数基本不受粉末样品粒度影响，可以使用块状标准物质对其RSF进行修正。通过对不同Mg含量梯度的样品进行考察，对Mg元素的RSF系数提出了校准方案。考虑到基体元素Ni对Mg元素的影响，在准确度要求较高时应根据实际Mg含量高低及粒度段范围建立两套RSF系数进行修正。同时给出了两套RSF系数的参考值，对Mg含量3 μg/g平均粒度200目的样品及30～300 μg/g平均粒度-80～+120目的样品相应的RSF参考值分别为1.16和0.41。

Abstract

In this paper，the relative sensitivity factor（RSF） of 14 key trace elements with three different particle size ranges of FGH96 superalloy powder were systematically analyzed by glow discharge mass spectrometry（GDMS），and the asymmetric charge transfer（ACT） theory was applied to the RSF coefficient correction problem of Mg element in nickel-based superalloys for the first time. The experimental results show that the RSF coefficients of 13 trace elements such as B，P，and S are basically not affected by the particle size of powder samples，and their RSF can be corrected by bulk standard materials. Through the investigation of samples with different Mg content gradients，a new calibration scheme was proposed for the RSF coefficient of Mg element. Considering the ACT influence of matrix element Ni on Mg element，two sets of RSF coefficients should be established according to the actual Mg content and particle size range for correction when the accuracy requirement is high. This paper gives the reference values of two sets of RSF coefficients. The corresponding RSF reference values for samples with Mg content of 3 μg/g and average particle size of 200 mesh and samples with Mg content of 30-300 μg/g and average particle size of -80～+120 mesh are 1.16 and 0.41，respectively.

关键词

镍基粉末高温合金痕量元素相对灵敏度因子不对称电荷转移辉光放电质谱法粉末粒度

Keywords

nickle based superalloytrace elementsrelative sensitivity factorasymmetric charge transferglow discharge mass spectrometrypowder size range

references

Zhang G Q，Tian S F，Wang W X，Li Z. Adv. Mater. Ind.（张国庆，田世藩，汪武祥，李周. 新材料产业），2009，11：16-21.

Furrer D，Fecht H. J. Miner. Met. Mater. Soc.，1999，51：14-17.

Zhang G Q，Zhang Y W，Zheng L，Peng Z C. Acta Metall. Sin.（张国庆，张义文，郑亮，彭子超. 金属学报），2019，55（9）：1133-1144.

Zhang Y W，Liu J T. Mater. China（张义文，刘建涛. 中国材料进展），2013，32：1.

Hu B F，Liu G Q，Jia C C，Tian G F. J. Mater. Eng.（胡本芙，刘国权，贾成厂，田高峰. 材料工程），2007，2：49-53.

Thomas N，Jozsef P. Appl. Spectrosc. Rev.，2006，41（3）：227-258.

Meng Y L. Chin. J. Anal. Lab.（蒙益林. 分析试验室），2008，27（S）：430-433.

Gao S，Pang X H，Zhang Y，Chen J，Liang K. Phys. Test. Chem. Anal.：Chem. Anal.（高颂，庞晓辉，张艳，陈靖，梁钪. 理化检验-化学分册），2023，59（3）：257-263.

Gao S，Liang K，Pang X H，Zhang Y，Zhang T，Zheng S B. Phys. Test. Chem. Anal.：Chem. Anal.（高颂，梁钪，庞晓辉，张艳，张涛，郑松波. 理化检验-化学分册），2022，58（9）：1056-1062.

Yu X，Li X J，Wang H Z. Metall. Anal. （余兴，李小佳，王海舟. 冶金分析），2004，24（z1）：152-156.

Ganeev A，Gubal A，Uskov K，Potapov S. Russ. Chem. Bull.，Int. Ed.，2012，61（4）：752-767.

Wei X J，Wang L P，Qin Z，Zhang H L，Deng D C. J. Chin. Mass Spectrom. Soc.（魏兴俭，王丽萍，秦震，张海路，邓大超. 质谱学报），2016，37（4）：343-350.

Marcus R. Glow Discharge Plasmas in Analytical Spectroscopy. England：John Wiley & Sons，Ltd，2002：71-96.

Wei X J，Qin Z，Xiong P H，Wang L P，Zhang H L，Deng D C，Liao J S. Spectrochim. Acta B，2019，154：43-49.

Steers E，Fielding R. J. Anal. At. Spectrom.，1987，2：239-244.

Bogaerts A. Spectrochim. Acta B，2009，64（11/12）：1266-1279.

Korolov I，Bánó G，Donkó Z. Spectrochim. Acta B，2011，66（9/10）：706-711.

Busam J，Stokkan G，Muggerud A，Sabatino M. J. Mass Spectrom.，2021，56（8）：1-8.

Annemie B，Krassimir A，Nikolay K，Renaat G. Spectrochim. Acta B，2007，62（4）：325-336.

Rapp D，Francis W. J. Chem. Phys.，1962，37：2631-2645.

Sohail M. J. Anal. At. Spectrom.，2020，35：1814-1826.

Mushtaq S，Steers E，Churchill G，Barnhart D，Hoffmann V，Pickering J，Putyera K. Spectrochim. Acta B，2016，118：56-61.

Bogaerts A，Gijbels R. J. Anal. At. Spectrom.，1996，（11）：841-847.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Determination of Oxygen and Nitrogen Elements in Nickel-based Superalloys by Glow Discharge Mass Spectrometry

Calibrated Relative Sensitivity Factors for Elemental Quantitative Analysis of Trace Rare Earth & Precious Metal Elements in Nickel Base Superalloy by Glow Discharge Mass Spectrometry with Fast-flow Ion Source

Related Author

ZHANG Zhong-yuan

LI Hui

WANG Chang-chun

LI Xiao-xu

QU Hua-yang

WANG Hai-zhou

YANG Guo-wu

HU Jing-yu

Related Institution

Institute of Metal Research，Chinese Academy of Sciences

Central Iron & Steel Research Institute

The NCS Testing Technology Co.，Ltd.

Address：100 Xianlie Middle Road, Guangzhou Postal code：510070
Tel：020-87684776,37656606 Fax：020-87684776 Email：fxcsxb@china.com
Technical support is provided by Beijing Founder electronics co., LTD 粤ICP备12017312号-3 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰